Maybe it's time to Repower
How to tell when you should repower;
"Do you know the right time?"
Greens grooming equipment can be expensive enough that you’d rather repair than replace – but when one of your mowers or rakes starts sputtering a bit on the start, or dies out halfway through the job, it’s tempting to decide that it’s time to go shopping. Before you decide to scrap your old equipment, go through these diagnostic tests. If the machine is still working, but the motor is dying, the best answer may be a new engine, not a new mower.
Keep in mind that a problem with one part of an engine could well show up as a symptom elsewhere. What looks like a governor problem often turns out to be a balky carburetor. Take the diagnostics step by step all the way through, then evaluate whether the engine is worth the trouble to repair it, or whether it makes more sense to buy a repower kit and drop in a new, more powerful motor.
Problem: The Engine will not start.
You can usually divide ‘won’t start’ problems into two causes: fuel or ignition.
- Make sure the fuel is fresh, and the oil/gas mix is right. As basic as that sounds, bad gas is one of the most common causes of engine failure.
- Check for spark. Remove a spark plug and ground the hex to bare metal on the motor, then spin the engine. You should see a blue spark jump the gap. If the spark is weak, or there is no spark, try the same thing with a new spark plug. If you still get no spark on an older machine, clean and set the points. On a newer machine, the electronic ignition may need to be replaced.
If there’s a spark but there’s no start, it’s time to check the carburetor.
- Check fuel valve and lines to be sure that fresh gas is getting to the carburetor. Don’t forget to check the screens to be sure that they’re clear, and that the fuel cap vent is open.
- Prime the carburetor with a shot of starting fluid and try to start ‘er up. If she runs for a couple of seconds then quits, it’s a good bet that the carburetor needs to be rebuilt. A carb kit with quality parts is easy to install. Most dealers will carry a wide assortment of Toro parts and other quality brands.
- The other possibility here is an air leak. Check all the mounting screws and bolts to be sure that they’re snug, and that the gaskets are intact.
Problem: Engine start but runs poorly. (Dies, surges, runs only on choke)
These could be symptoms of a carburetor problem. 90% of the time, a good cleaning will solve the problem. That means disassembling, cleaning and rebuilding – which will go far more smoothly if you use the engine manual as your guide.
MISC. ENGINE PROBLEMS
When your motor springs an oil leak or spouts smoke, it’s trying to tell you something. The color of the smoke and the location of the leak can point to problems that need fixing – or tell you that it’s time to repower the mower with a new Kohler or Jacobsen Greens King engine.
Oil smoke or leak near the carburetor can mean the drain holes in the breather cover need to be cleaned. Don’t forget to replace the gasket with a new one picked up at any store that stocks Kohler, Toro Greensmaster or Jacobsen Greens King parts.
Oil smoke through the muffler can mean worn rings or worn valve guides. Either one of those is a hint that it’s time to repower that piece of equipment with a new Kohler, Cushman, Jacobsen Greens King or Toro engine.
Worn-out engines may have more than one problem. If you’d rather not spend the next several months pulling that same piece of equipment back into the shop for yet another repair, your best option may be a complete repower with a remanufactured or new Kohler, Cushman Frontline,Jacobsen Greens King or Toro engine.
© Ben Anton, 2006
Stay Up to date on all the latest Repower info ---> Repower